This study discusses the economic utilization of proton exchange membrane fuel cell (PEMFC) based on cost of energy (COE) to supply residential electrical and thermal loads. The fuel cell system is sized using simplified mathematical expressions considering the stack degradation and the system salvage value at the end of its life time. The study is based on a 5 kWh/day residential load with a peak load power of 1300 W. Two scenarios for economic survey are studied. The first scenario is to find the commercial price for each FC component considering that the supply fuel is hydrogen. The other scenario is for a complete FC system commercial price considering that the supply fuel is natural gas. The economic analyses are based on the actual sale prices in the market. The COE of the fuel cell system is compared with previous work by the authors for the same residential ratings but supplied from a stand-alone photo voltaic system (SAPV). The analysis results show that the COE relies heavily on the capital cost of the system.
Mekhilef S. , Saidur R., Safari A. (2012), Comparative study of different fuel cell technologies. Renewable and Sustainable Energy Reviews, 16(9), 981–989.
Wang, Yun , et al. (2011), A review of polymer electrolyte membrane fuel cells: Technology, applications, and needs on fundamental research. Applied Energy, 88(4), 981–1007.
Nelson D. B. , Nehrir M. H., Wang C. (2006), Unit sizing and cost analysis of stand-alone hybrid wind/PV/fuel cell power generation systems. Renewable Energy, 31(10), 1641–1656.
Kuhn R. et al. (2012), Dynamic fuel cell gas humidification system. International Journal of Hydrogen Energy, 37(9), 7702–7709.
Harikishan Reddy E. , Jayanti S. (2012), Thermal management strategies for a 1 kWe stack of a high temperature proton exchange membrane fuel cell. Applied Thermal Engineering, 48, 465–475.
Zhang Guangsheng , Kandlikar S. G. (2012), A critical review of cooling techniques in proton exchange membrane fuel cell stacks. International Journal of Hydrogen Energy, 37(3), 2412–2429.
Colozza A. J. , Burke K. A., NASA Glenn Research Center (2011), Evaluation of a passive heat exchanger based cooling system for fuel cell applications. Cleveland, Ohio: National Aeronautics and Space Administration, Glenn Research Center.
Teymouri H. F. , Sattari S. (2011), Technical and economic feasibility study of using Micro CHP in the different climate zones of Iran. Energy, 36(8), 4790–4798.
Yu, Yi et al. (2011), Comparison of degradation behaviors for open-ended and closed proton exchange membrane fuel cells during startup and shutdown cycles. Journal of Power Sources, 196(11), 5077–5083.
Yu, Yi et al. (2012), A review on performance degradation of proton exchange membrane fuel cells during startup and shutdown processes: causes, consequences, and mitigation strategies. Journal of Power Sources, 205, 10–23.
Zhou Keliang , Ferreira J. A., De Haan S. W. H. (2008), Optimal energy management strategy and system sizing method for stand-alone photovoltaic-hydrogen systems. International Journal of Hydrogen Energy, 33(2), 477–489.
Hung Ai-Jen et al. (2008), Cost analysis of proton exchange membrane fuel cell systems. AIChE Journal, 54(7) 1798–1810.
Fuel Cell Handbook (2004), 7th ed. EG&G Technical Services, Inc., USDOE.
Graetz J. (2009), New approaches to hydrogen storage. Chemical Society Reviews, 38(1), 73–82.
Verstraete D. et al. (2010), Hydrogen fuel tanks for subsonic transport aircraft. International Journal of Hydrogen Energy, 35(20) 11085–11098.
Wan Z. M. et al. (2012), Water recovery and air humidification by condensing the moisture in the outlet gas of a proton exchange membrane fuel cell stack. Applied Thermal Engineering, 42, 173–178.
Magistri L. , Traverso A., Massardo A. F., Shah R. K. (2006), Heat exchangers for fuel cell and hybrid system applications. Journal of Fuel Cell Science and Technology, 3(2), 111–118.
Azmy A. M. (2005), Simulation and management of distributed generating units using intelligent techniques. PhD Thesis, Faculty of Engineering, University of Duisburg-Essen, Germany.
Carlson E. J. , Kopf P., Sinha J., Sriramulu S., Yang, Y. (2005), Cost Analysis of PEM Fuel Cell for Transportation Systems, National Renewable Energy Laboratory NREL, Report No. NREL/SR-560-39104.
Spendelow J. , Marcinkoski J. (2012), Fuel cell system cost– 2012. US Department of Energy Hydrogen and Fuel Cells Program, Report 12020.
Bartels J. R. , Pate M. B., Olson N. K. (2010), An economic survey of hydrogen production from conventional and alternative energy sources. International Journal of Hydrogen Energy, 35(16), 8371–8384.
Oh Si-Doek et al. (2012), Optimal operation of a 1-kW PEMFC-based CHP system for residential applications. Applied Energy, 95, 93–101.
Matsuura T et al. (2013), Degradation phenomena in PEM fuel cell with dead-ended anode, International Journal of Hydrogen Energy.
Hawkes A. D. , Brett D. J. L. Brandon N. P. (2009), Fuel cell micro-CHP techno-economics: Part 2 – Model application to consider the economic and environmental impact of stack degradation. International Journal of Hydrogen Energy, 34(23), 9558–9569.
http://www.horizonfuelcell.com, accessed on 8/9/2014.
One of the fuel cell R&D firms in the US : http://www.fuelcellsetc. com/store/, accessed on 11/9/2014.
Energy Information Administration. U.S. natural gas prices , http://www.eia.gov/dnav/ng/ng_pri_sum_dcu_nus_m.htm
Zoulias E. I. , Lymberopoulos N. (2007), Techno-economic analysis of the integration of hydrogen energy technologies in renewable energy-based stand-alone power systems. Renewable Energy, 32(4), 680–696.
Makhmalbaf A. et al. (2014), Lesson Learned from Technical and Economic Performance Assessment and Benefit Evaluation of CHP-FCS.
http://www.nuvant.com, accessed on 11/9/2014.
http://panasonic.co.jp/corp/news/official.data/data.dir/2013/01/en130117-5/en130117-5.html, accessed on 9/9/2014.
http://enefield.eu/, accessed on 9/9/2014.
http://en.wikiversity.org/wiki/Design_for_the_Environment/Residential_Micro-cogeneration, accessed on 9/9/2014.
Adams A. (2011), Cost analysis comparison of bloom energy fuel cells with solar energy technology and traditional electric companies. PhD Thesis, San Jose State University.
Sherif M. , Ahmed M., Rashad E. (2014), Sizing and Economics Analysis of Standalone PV System for Residential Utilization, MEPCON’14, Cairo, 13–15 December, 2014.